|
|
PLAY CENTRES - GENERAL INFORMATION PAGE
All of our play centres are designed to be both attractive and durable for years of enjoyment by children everywhere. For further technical information on all play centres and play centre accessories please call Debbie on 01553 811717 during normal office hours.
|
INSTALLATION INFORMATION
Before installing your play centre it is extremely important to ensure that the complete surface is level. The site must be at least 6 feet from any structure or obstruction such as a fence, garage or house, overhanging branches, clothes line or overhead wires. Do not install the play centre over concrete, asphalt or any other hard surface. A fall on to a hard surface can result in serious injury. For advice on ground cover recommendations for your particular desired installation, please feel free to call Debbie on 01553 811717 for further information.
|
OPERATING INSTRUCTIONS
- Two rope swings are designed for one person only with a maximum weight of 150lbs.
- Children should be dressed appropriately and the use of scarves and other loose clothing that may be hazardous whilst using the play equipment should be avoided.
- Children should be adequately supervised at all times.
- Children should be instructed to avoid walking close to, in front of, behind or between moving items.
- Children should be instructed not to twist swing ropes / cables or loop swings over the swing beam as this may reduce their strength.
- Children should be instructed to sit properly in the centre of swing seats.
- Chldren should be instructed not to use the play centre in any other manner than intended.
- Children should be instructed not to get on or off equipment such as swings while the equipment is in motion.
- Children should be instructed not to use the play centre when it is wet or slippery.
- The easy climb ladder is intended for use by one person only with a maximum weight capacity of 180lbs.
|
MAINTENANCE GUIDE
- Check all nuts and bolts twice monthly during the regular usage season and tighten as required. It is particularly important that this procedure be followed at the beginning of each season.
- Ensure adequate ground cover is maintained. Top up any worn or low areas especially under swings and slides.
- After installation check for sharp edges on any wood parts that may need to be sanded down, and periodically thereafter for rough spots.
- Check swing elements monthly for wear and replace if necessary. Removing swings and storing when not in use when the temperaure drops to or below freezing point will prolong the life of swings, seats and ropes.
- Applying a good quality sealer to all wood parts is recommended to lessen weather checking.
|
LIMITED WARRANTY
The manufacturer warrants its merchandise against defects for a period of one year. It further warrants all non moving wood parts against rot, decay and insect damage which impair the structural integrity of that product, for a period of 20 years on pine play centres and 10 years on redwood play centres from the date of purchase by the original owner. Due to the natural characteristics of the timber, warping and weather checking are not covered. These warranties do not cover normal wear and tear or damage resulting from misuse, abuse, altered or improperly installed equipment. All outdoor wood play centres and products require maintenance and a wood sealer and / or stain should be applied on all wood soon after assembly. Timber should be stored in a shade area until assembly.
Your child's safety is your responsibilty, so please inspect the equipment fully on a regular basis.
The manufacturer reserves the right to make changes in design and materials without notice.
|
::: Safety Rail Pads :::
|
Product picture image (Safety Rail Pads) is for illustration purposes only.
|
Safety pads are specially designed to protect your children from unexpected bumps and they should be ideally attached to all points of entry or exit to the play centre.
|
|
::: Platform Construction :::
|
Product picture image (Platform Construction) is for illustration purposes only.
|
The 4 inch by 4 inch corner uprights of the play centres are wrapped with the heavy duty deck frame for strength and the corners are braced with steel for rigidity in construction.
|
|
::: Horizontal Ladder Rings :::
|
Product picture image (Horizontal Ladder Rings) is for illustration purposes only.
|
Powder coating provides a tough durable finish to the steel rungs used in the construction of the horizontal ladder part of the play centre. The ladder rings are resistant to chips and scratches..
|
|
::: Steel Braces :::
|
Product picture image (Steel Braces) is for illustration purposes only.
|
All steel braces are powder coated for durability. The steel braces add strength to all stress points on the play centre and they eliminate wobble that occurs on most bolt through constructed play centres.
|
|
::: Durable Hardware :::
|
Product picture image (Durable Hardware) is for illustration purposes only.
|
Heavy duty, rust resistant safety screws, nuts and bolts are used throughout all play centres for maximum strength and durability.
|
|
::: High Quality Ropes :::
|
Product picture image (High Quality Ropes) is for illustration purposes only.
|
Strong double braided polypropolyne rope makes the swings and climbing ropes the softest to the touch and longest lasting available on any modern play centre.
|
|
::: Rope Clamps :::
|
Product picture image (Rope Clamps) is for illustration purposes only.
|
The rope clamps used within the play centres are custom designed to ensure that the rope is wrapped and gripped for maximum security and safety.
|
|
::: Swing Hangers :::
|
Product picture image (Swing Hangers) is for illustration purposes only.
|
Swing hangers are of a proven design with deep lag threads, tough nylon bushing and a J-style end to eliminate improper installation. and ensure maximum safety considerations.
|
|
